Engine
Troubleshooting Diesel Engine Hard Starting, Low Power and Exhaust Smoke
Top problems for diesel owners. Kent recommends starting with the basics
What's wrong with my Mercedes?
Engine Problems
Engine
Increasing Turbocharger Performance on Diesel Engines
Don't just ignore your turbo charger or major problems can occur!
Engine
Diesel Won't Shut Off When the Key is Turned Off
Could be any number of things causing the problem. Proper diagnosis is a must!
Engine
Finding the Best Diesel Performance Upgrade
Injectors do not last forever. Changing over to Monark nozzles can boost performance!
Engine
Oil Cooler Hose Leaks and Failure on Older Mercedes (especially OM 616 and OM 617 Diesels)
Failure of these hoses can lead to total destruction of your engine
Engine
1984 to 1995 601 602 603 Diesel Performance Enhancement
Quick list of things you can consider to increase performance and mileage
Engine
Preventing Catastrophic V8 Engine Failure
Plastic guide rails and oiler clips can fail leading to major engine damage
Engine
Bad Motor Mounts can Ruin a Diesel Engine
Yes, Kent has seen it first hand. Don't neglect this!
Engine
617 Turbo Diesel Engine Rack Damper (Idle Stabilizer) Adjustment
This can help smooth out a rough shakey idle on an 5 cylinder turbo diesel
Engine
How to Determine if Your Diesel Engine is Worn Out
Before spending any money on a tired or ailing diesel engine - check the compression first
Engine
615 616 617 Diesel Engine Timing Chain Routing and Parts Needed
Good reference material if you plan to replace timing chain and related parts.
Engine
Diesel Injection Pump Timing
Timing tends to retard over time with wear and chain stretch
Engine
Diesel Engine Oil Leaks
Most of those annoying leaks can be fixed with our DIY kits
Engine
Engine or Climate Control Heater not Getting Hot
It is almost always a failed thermostat
Engine
Inspecting the Voltage Regulator BEFORE it Fails and Leaves You Stranded
Do it very soon unless you know it have been done within the last 50,000 miles.
Engine
My 102 103 104 Gas Engine Just Won't Start
There are a number of reasons - don't throw money at the problem - diagnose first!!!
Engine
Diagnosing Diesel Engine Knocking Noises
Diesel Purge can help you isolate the noise
Engine
Hard Starting Gas Engine
Don't neglect the fuel filter and fuel pump check valves
Engine
Changing Your Power Steering Pump and Filter
This is often neglected and an easy D.I.Y. job
Engine
Preventing Bolt or Thread Seizure
A special compound should be used - especially with steel bolts in aluminum threads
Engine
617 Turbo Diesel Timing Chain Tensioner Installation
This MUST be installed properly when replacing it or timing chain or engine damage can occur!
Engine
Removing Stubborn Spark Plug Wires from a M102 or M103 Gas Engine
Doing it without damaging the wire boot and resistor is easy with the right tool
Engine
Isolating a Diesel Engine External Rattling Noise
Usually means something is broken or loose in the engine compartment
Engine
Worn Timing Chain and Guides
Failure of these chains can lead to catastrophic engine failure
Engine
Keeping the Power Steering Fluid Clean
Many are surprised to learn there is a filter down inside the pump
Engine
The Challenge of Overhauling a 615, 616, or 617 Diesel Engine
Applies to 220D 240D 300D 300CD 300TD 300SD 1972 to 1985
Engine
Exhaust and Intake Manifold Gasket Leaks on Older Diesel Engines
Alert for all Diesel Owners - Check for loose Intake / Exhaust Manifold Nuts.
Engine
Avoiding Engine Trouble When Running Vegetable Oil in your Diesel
Fuel injectors will need the most attention
Engine
617 Turbo Diesel Loud Engine Rattle Noise
Common problem due the failed air cleaner mounts and mounting bracket
Engine
Buying a Mercedes W126 300SDL
Milestone 6 cylinder diesel only available in 1986 and 1987
Engine
Should I Buy a Cheap Mercedes?
6 part video series on reasons why you should or shouldn't
Engine
Understanding and Testing the EGR Valve
Find out what it does, how to test it, and what happens if it does not work.
Engine
I Can’t Get My Old Distributor Lined Up So Points Are Timed Right
This is especially important when installing an aftermarket electronic ignition
Engine
Loose Alternator Belt on 1970's Models
Adjustment procedure must be followed properly!!!
Engine
Rattle Noise Coming From the Front of the Engine
Fan clutch can make metallic clinking noises
Engine
Removing Stuck Radiator and Coolant Hoses
An old hose can be very difficult to remove due to age and corrossion
Engine
Buying a Used Mercedes Quick Check No. 1
Your inspection should always include this
Engine
Dealing with Problem Engine Studs
How to get the frozen nuts off and the stud back in safely
Engine
What Does a Healthy 240D Diesel Engine Sound Like
Listen and learn from a live video with sound.
Engine
How to Make Diapers for Engine Oil Leaks
Not Tested on Humans, Yet.
Engine
What Maintenance is Required After Buying an Old Diesel?
Throttle Linkage Inspection, Service and Repair
Engine
Leaking Mufflers and Exhaust Pipes
If not too far gone you can fix them - and yes it is a miracle!
Engine
Checking for Slow Power Steering Fluid Leaks
Check Your Low Pressure Power Steering Pump Hose
Engine
Garrett T3 Turbo Removal from Turbine Housing
Sometimes it can be near impossible to get the bolts out and the parts separated
Engine
Breaking Free Frozen Hex Bolts: Part 1
At all costs avoid rounding out the hex head of the bolt!
Engine
Engine Won't Start? Could It Be the Distributor Cap?
You would be amazed at the pesky problems these can create!
Engine
Where in the World Can You Get a Good Shop Light?
You may have to make your own like Kent did...:-)
Engine
Is a Third Wrench Needed When Adjusting the Valves on an Old Diesel?
This is how Kent deals with the problem
Engine
How to Restore the Paint on Your Black Engine and Chassis Parts
With the right paint and technique YOU can do it yourself!
Engine
What Causes Early Diesel Engine Death?
Besides Lack of Oil Changes
Engine
Do You Have Any Tips on Installing New Heat Shield Washers When Replacing Diesel Fuel Injectors?
Engine
Checking Out a Diesel Engine Before Purchase
Here are some quick checks you can do yourself to determine how good the engine is.
Engine
Planning a Long Road Trip in an Old Benz?
Just I Jump in and Go? NO!
Engine
Identifying a late 1984 or 1985 617 Turbo Diesel Engine with Trap Oxidizer
Parts are different so it is important to know which engine you have!
Engine
Curing the Common Valve Cover Oil Leak on the OM616 and OM617 Diesel Engines
A very common problem that requires MORE than just installing a new rubber gasket
Engine
Testing and Adjusting Turbo Charger Waste Gate Assembly
A faulty 617 turbo diesel waste gate can really affect engine performance
Engine
How Hard is it to Change the Glow Plugs?
With the right instructions this is a beginner DIY job.
Engine
Are There Better Shop Work Lights Out There?
Kent has been inspired to design his own series of ultimate shop lights
Engine
Challenges to Owning a 1985 Model W123 or W126 Diesel
Quite a number of changes for just a one year and final run of the 300D 300CD 300TD 300SD
Engine
Challenges When Doing Valve Adjustment on Early Gas Engines
Special tools are needed but you can still run into problems
Engine
What's The Best Way to Troubleshoot Engine Noises
AND Pinpoint The Cause
Engine
Fan Belt Noises
They can be a little tricky to isolate
Engine
Rubber Exhaust Hanger ( Donut ) Replacement
These can be a little tricky to get on
Engine
Challenges Restoring a 123 Chassis Diesel
Thoroughly check the car and especially the engine before spending big $$$
Engine
Curing an Intermittent Rough Running Diesel Engine
This can be a real challenge if the problem comes and goes either warm or hot
Engine
Removing a Broken Off Glow Plug
Not easy by any means. Options and ways to prevent it are listed here.
Engine
Using the Wrong Gasket Sealant
If you use RTV you can create some real problems
Engine
Removing a Power Steering Pump Pulley
Most often this can be done without special tools using a helper and a heavy hammer
Engine
How to Get a Glow Plug Out Without Removing the Injector Lines
Some special tools can help
Engine
Why is my 300D So Slow?
Part 1 and 2
Engine
Why is My Heater So Sporadic?
On Most 1981 to 1991 Mercedes Benz
Engine
Diesel Engine Front Crank Bolt Failure and Loss of Pulleys
Pay attention! This is very common and can happen to you if you own a 1968 to 1985 diesel
Engine
Finding a Use for Old Diesel Engine Parts
Sometimes you just have to take a break from working on your diesel... :-)
Engine
Finding a Strange Ticking Noise in an Alternator
If you don't look closely this one can be hard to find!
Engine
Restoring a 1950's and 1960's Era Mercedes that has been stored
If the car has been stored or not driven regularly plan on some problems - some may be hidden!
Engine
Draining Oil Out of Your Engine
The best way is to use an oil extractor
Engine
Changing Oil in My 1998 to 2006 Mercedes
A simple procedure if you have the V6 (M112) or the V8 (M113) Engine
Engine
Problems Adjusting Diesel Valve Clearances
You of course need the right wrenches - but if one or more won't adjust - what then???
Engine
Badly Pitted Water Pump or Thermostat Housing Hose Nipple
If you don't fix it the problem will get worse and the coolant hose will leak
Engine
How to Tell if Your Thermostat is Failing?
Monitor your engine temperature gauge in the morning for telltale signs.
Engine
Is Your M Class Leaking Oil From the Breather?
It's common problem but luckily you can fix it yourself!
Engine
Using Silicone RTV Gasket Adhesives
Alert! Use at your own risk
Engine
Challenges Purchasing an early to mid 1990's Model Mercedes
Do your homework and proceed carefully BEFORE buying! Type of Problem: troubleshooting
Engine
Diesel Engine Smoke and Lack of Power Problems - A Quick Reference Solutions Guide
Summary list of the most common causes and parts needed to fix them Part 2 of 5
Engine
Garrett T3 Compared to KKK Turbo Charger
How to tell which one you have?
Engine
Excessive Engine Oil at the Inlet or Outlet of the Turbo Charger
It could be turbo seals but it could also be excessive diesel engine blow-by
Engine
Avoiding Internal Engine Corrosion
You neglect the maintenance here and you WILL pay the price
Engine
Cleaning Old Engine Aluminum Parts
How can you do it without removing them from the engine?
Engine
How to do OVER THE TOP Engine Compartment Detailing
It takes work but with the right products and techniques you will be amazed
Engine
Kent's Favorite Engine Oil for High Mileage Cars
And His Reasons Why
Engine
Why is This Mercedes 300D So Slow? - Part. 1
Don't Neglect to Check Simple Things First
Engine
Plastic Radiator Neck Failure
An ounce of preventation is worth hundreds of dollars in repair
Engine
Removing Rounded Out or Damaged Hex Head Bolts
Avoid the pain of having to drill or cut the bolts off
Engine
Gas Engine Runs Rough
Sometimes fuel injector cleaner can work wonders
Engine
Diesel Engine Starting Problems - A Quick Reference Solutions Guide
Summary list of the most common causes and parts needed to fix them
Engine
Keeping Things in Place - On and Off a Car
This is Kent's favorite
Engine
Plastic Radiator Neck Failure - It Can Happen Anywhere and to Anyone!
Even low mileage gas Mercedes as Kent recently discovered.
Engine
Removing a Stubborn Power Steering Pump Pulley
Sometimes they are really stuck on the shaft!
Engine
How to Easily Add Life to Your Old Benz
You can do it with magnets!
Engine
I Installed a New Timing Chain and It "Jumped" Some Sprocket Teeth
Now the timing marks don't line up - What do I do! - Help...
Engine
How Can I This Little Trick Help Your Mercedes Run Smoother, Idle Better and Easily Accelerate?
It's Such a Small Procedure This Video Instruction is Only 2 Minutes in Length!
Engine
Diesel Engine Camshaft Inspection and Adverse Wear
This can be a sign that the engine has not been well maintained
Engine
Engine Oil Leaks On Your 201 124 and Late 126 Chassis
Catch them with a diaper before they drip on the ground!
Engine
Getting an Old Mercedes Diesel to Start Quicker
Tired of waiting for the glow plugs to heat up - we have the answer!
Engine
Diesel Engine Shut Off / Stop Problems - A Quick Reference Solutions Guide
Summary list of the most common causes and parts needed to fix them Part 3 of 5
Engine
Troubleshooting Front Engine Noises on Newer Models
It will require the removal of the serpentine belt
Engine
Finding a Replacement Turbo Diesel Oil Cooler
Some are no longer available new and the last ones will disappear soon
Engine
Cleaning an Old Dirty Oily Diesel Engine
There is a better and cleaner way!
Engine
Swapping Different Engines into My Old Tired Diesel
When you engine wears out - look seriously at swapping in a different engine
Engine
616 617 Used Diesel Engine Transplant / Major Service Requirements
Don't just install the engine without taking care of a number of potential problems
Engine
Locating the OM616 and OM617 Internal Engine Timing Marks
These can be hard to see if your engine is dirty and you don't know the exact location
Engine
Diesel Engine Fluid Leak Problems - A Quick Reference Solutions Guide
Summary list of the most common causes and parts needed to fix them. Part 5 of 5
Engine
How to Determine the Real Condition of a Used Engine
It is best if you can see and hear it run - if not some tests are essential
Engine
Worn Out Engine Motor Mounts
How to determine if they need replacement
Engine
My 190E 300E 300SE 300SEL Won't Start or Just Quits While Driving
The distributor cap has become the number one culprit due to age and neglect!
Engine
102 103 Engine Oil Consumption and Blue Smoke
A common problem due to failed valve guide seals
Engine
Troubleshooting Diesel Engine Overheating
It could be a number of things causing the problem. Follow Kent's video series
Engine
Easy way to Drain Coolant from the Radiator
Applies to most models from 1980 to 1995
Engine
Problems You Might Encounter Running Biodiesel
Biodiesel is not too kind to rubber
Engine
Diesel Engine Knock and Noise Problems - A Quick Reference Solutions Guide
Summary list of the most common causes and parts needed to fix them Part 4 of 5
Engine
Diesel Motor Mount Bolt or Thread Damage
A real problem when changing an engine or the rubber mounts
Engine
What is Wrong with This Rough Running D-Jetronic V8 Engine?
I Bet You Can't Guess It
Engine
Not All Air Filters Are Created Equal - Some Even Allow Dirt to Get By
Shocking I know!
Engine
Keeping Your Engine and Engine Compartment Clean and Detailed
Are you concerned about damage to the electrical components and sensitive electronics?
Engine
Bad Diesel Engine Oil Leak at Front Crank Seal
We have a special kit with complete instructions so you can fix it yourself.
Engine
Starter Motor Grinds When I Turn the Key - How to Bench Test?
Could be the starter itself, ring gear on the flywheel or a combination of both
Engine
Possible to Fix a Broken Off Plastic Tank Radiator Neck?
If the break was clean and the tank still solid you can be repair it for less than $50.
Engine
What Oil and Fitler to Use? How Often Should I Change It?
These questions become more important with the long oil change intervals associated with Synthetic Engine Oil
Engine
Where is Your 1977 - 1985 Mercedes is Leaking Oil From?
Watch my short 4 minute video to find out!
Engine
Oxygen 02 Sensor Removal
Sometimes having the right tool is key
Engine
Diesel Injectors Still Not Working Properly After Rebuild
It is not the problem with the new nozzle - there are other issues that cause poor spray
Engine
Garrett T3 Turbocharger Waste Gate Problems
You MUST make sure this is working and adjusted properly if you want your diesel to GO !!!!
Engine
How to Clear the Check Engine Light: 1988 to 1995 OBD1 models
Very easy to do if you know what to do with that little numbered black box!
Engine
Excessive Oil in the Intake and Compressor on Turbo Diesel Engines
This is normally not due to "leaking seals" inside the turbo charger
Engine
How to Prevent Problems When Your Benz is Stored Over Winter
Do not neglect to give it Kents 30 day exercise program
Engine
Why are The Water Pump Bolts Always So Rusty?
Is There a Solution?
Engine
Slow Loss of Coolant and Minor Drips Around and Under Radiator or Coolant Tank
Be sure to check your radiator / expansion tank cap
Engine
Securing Rubber Exhaust System Hangers (Donuts)
They can fall off especially if your exhaust system is sagging or not mounted properly
Engine
Throttle Linkages Binding
Ball joints and pivot points should be lubricated on a 6 to 12 month basis
Engine
Rotating Your Engine During Service and Maintenance
Best done from the front crankshaft bolt
Engine
Gas or Diesel Engine Runs Too Hot or Too Cold
Too Cold think thermostat - too Hot think a number of possible causes
Engine
Temporary or Emergency Repair Kit Contents? - Especially When on the Road
Here are some of Kent's favorites - most you should carry in your trunk
Engine
Inspecting and Replacing Rubber Exhaust Hangers
With the right tool and a little know-how it is super easy.
Engine
Cleaning Large Engine Parts
You actually may not need a large tank to thoroughly clean them
Engine
Raining W126 300SDs in PNW: Guess What is Weird on This Turbo Diesel Engine?
And no, it's not me! Haha
Engine
Diesel Engine Transmission Torque Converter Flex Plate Failure
This can be difficult to diagnose
Engine
616 617 Diesel Starter Motor Replacement (1969 to 1985)
On some models this can be a difficult and frustrating job
Engine
Overhauling the OM 602 and 603 Turbo Chargers
We can only offer limited support due to low demand
Engine
They Said it Only Needed a Head Gasket!
If the engine has been overheated it is almost never "just a head gasket"
Engine
What Engine Oil Should I Use???
Opinions abound - Kent can only share his...
Engine
1976 to 1993 Gas Engine Shakes at Idle ( Runs Rough )
4 key performance related issues to consider. Do proper troubleshooting first BEFORE buying parts
Engine
Why Does My V8 Timing Chain Need Replacement
Addition Safety Tips in This Video
Engine
Overview Mercedessource New Shim Kit: s
For Adjusting Diesel Fuel Injector Release Pressures
Transmission Problems
Transmission
Diagnosing, Adjusting and Fine Tuning Mercedes Automatic Transmissions
You CAN do this yourself if you have the right information and equipment!
Transmission
Automatic Transmission Erratic Shifts
Proper diagnosis is priority one - then repair! DIY testing and repair kits available.
Transmission
Transmission Oil Leaks
Some leaks are not difficult to fix. Others require removal of the transmission
Transmission
Does Your Automatic Transmission Really Need Replacing?
Be careful to not let someone sell you a rebuilt transmission!
Transmission
Component Failures Due to Lack of Lubrication
You might be surprised at just how many problems and failures could be avoided with periodic and proper lubrication
Transmission
Rattling or Loose Automatic Shifter Linkage
New bushings will solve the problem and possibly prevent disaster
Transmission
Installing New Seals in the Engine, Transmission or Rear End
Care must be exercised to prevent damage or premature failure
Transmission
Filling an Automatic Transmission to the Correct Level
A medium frustration for most of us who service our own transmissions
Transmission
Dealing with an Over Filled Automatic Transmission
A major frustration for most of us who service our own transmissions
Transmission
What To Use in Place of Dexron III Automatic Transmission Fluid?
Watch the video and Kent will explain his recommendations.
Transmission
How Can I Possibly Replace my Shift Bushing by Myself?
Try all you can. It's almost impossible without this special tool!
Transmission
Sloppy or Rattling Transmission Shifter?
May NOT Be the Shift Rod Plastic Bushings
Transmission
Broken or Leaking Transmission Bowden Shift Control Cable
Both problems require removal and it can be a little "tricky"
Transmission
Planning a Long Road Trip in Old Benz Part 2
Avoid a Stuck Throttle!
Transmission
Reviving a High Mileage Automatic Transmission
How to improve performance and prolong the life of a tired gas or diesel automatic transmission
Transmission
Diesel Automatic Transmission Oil Cooler Line Wear
This can leave you stranded if not caught early enough
Transmission
How to Check the Fluid Level in Mercedes 722.6 "Sealed for Life" Transmission
1998 to 2006 W202 W203 W204 W210 W211 W220 and M Class
Transmission
Repairing Leaking Transmission Cooler Metal Pipes on Older Diesels
Often caused by loose fittings and engine vibration
Transmission
What's Wrong Help Needed - Quick Links to the Most Common Problems
If you could just figure out what is wrong you know you could fix it!
Transmission
Preventing Transmission Oil Pan Leaks
Be Kind to Your Transmission Pan Gasket!
Transmission
Isolating and Repairing Diesel Engine Fluid Leaks
Find the actual source of the leak before jumping to conclusions
Transmission
How Do You Change Rear End and Manual Transmission Fluid
You Bet - The Easy Way!
Transmission
Mercedes Automatic Transmission Won't Upshift PART 2 - Steps to Solving Shifting Problem
Transmission
Checking Automatic Transmission Fluid Level
There is a proper way to do this to determine proper level inside transmission
Transmission
How do I inspect the transmission and related components on an Old Benz
Get a good light and get under the car.
Transmission
Manual Transmission Shift Linkage Binding
The transmission will bind or won't shift if worn bushings are out of adjustment
Transmission
1998 to 2006 722.6 Automatic Transmission Shifting Problems
If your transmission locks up in 2nd gear and won't shift there is hope!
Transmission
1968 to 1981 Automatic Transmission Won't Go Into or Slips Badly in Reverse
Yes, you are fortunate there is an adjustment!
Transmission
Measuring Automatic Transmission Fluid Level
Minor frustration for most of us who service our own transmissions
Interior Problems
Interior
Ignition Key Sticking or Jamming
Steps to diagnose and repair it before it becomes a MAJOR problem. Steps to fix it after it does!
Interior
Broken Down or Sagging Front Seat Bottom
D.I.Y. reinforcement kit available for 116, 123 and 126 chassis front seats
Interior
Inside Door Related Problems
Failure to do preventative maintenance could lead to some very expensive repairs
Interior
Ignition Tumbler / Key Wear
There are ways to reduce it - and we have ways to fix it!
Interior
Detailing Your Mercedes for Professional Results with Less Effort
Using the right methods and products are the key to the amazing results
Interior
Window Will Not Stay Closed Tight When a Regulator Fails
Here is a temporary fix until you get get the replacement parts
Interior
Ridding Your Interior of Ugly Spots and Stains
The key is in using the right products and techniques. Let Kent show you how.
Interior
Door Panel Removal
Can be frustrating and a little mysterious if you have not done it before
Interior
Non Air Bag Steering Removal
Can be problematic without using the correct tools and techniques
Interior
Inside Rear View Mirror Removal and Replacement
Improper technique can break the mirror glass or permanently damage the ball socket
Interior
Power Window Troubleshooting
When all else fails check the wiring
Interior
Outside Rear View Mirror Trouble
Removing it, replacing it, lubricating it, replacing the glass with out breaking it - you can do it!
Interior
How do I Remove and Repair My W116 or W123 Instrument Cluster?
Without breaking it.
Interior
Leaking Oil Under the Dash Below the Instrument Cluster
Sure sign of a common problem - leak in oil pressure gauge actuator
Interior
Drooping or Floppy Sun Visors
There is a simple fix to keep those old sun visors up
Interior
201 and 124 Chassis Door Panel Removal
Easy to damage if attempt is made to remove them improperly
Interior
W210 Chassis Door Related Problems
It all starts with the proper procedure for removing the door panel
Interior
Cracks in the Dash
You have a few options
Interior
Rear Seat Removal
Procedure very similar from mid 1970's to mid 1990's
Interior
W 126 Plastic Window Slides Keep Breaking
Find the real reason so you don't have to keep replacing them
Interior
W116 and W123 Broken Down Front Seat Swap
Broken, sagging, painful, tilting front seat bottoms ruin the driving experience!
Interior
What is that Left-Over Part After I installed a New Ignition Tumbler?
Only applies to certain models from 1984 to 1995. See list below
Interior
Dash Wood Coming Loose
This is something you can easily fix yourself
Interior
1982 Mercedes 240D X-Country Preparation
Why Take Off All 4 Door Panels?
Interior
123 Front Door Map Pocket Loose
Very common problem - easy fix once you remove the door panel
Interior
Adequate Lighting When Working Inside Your Car
Indoor lighting can be difficult. Kent has recently found the ultimate solution.
Interior
Turn Signal Lever Won't Hold Position When Pushed Up or Down
Tired of holding it up or down in a turn - Kent has a simple fix
Interior
Removing a Stuck Electric Power Front Seat
The seat has to be able to move back and forth in order to remove it!
Interior
Front Window Stuck in the Closed Position
How to get the regulator out the door when this happens
Interior
How Do I Find the Problem on My Glove Box Door?
And I Need Possible Solutions
Interior
Sagging Front Seat Back Net Map Pocket
You can fix it yourself with our simple kit
Interior
Removing a 1973 to 1985 Non-Airbag Steering Wheel
Care must be exercised to prevent damage to the steering lock mechanism
Interior
How to Fix Worn Color on Leather Seats
Get the right products and make a lasting repair yourself
Interior
Broken Manual Seat Adjustment Pull Handle
Very common problem on most 1970's and early to mid 1980's W123 and W126
Interior
Removing and repairing the W123 Glove Box Door
Hardest part is removing that weird round slotted nut on the lower hinges!
Interior
Door Panel Replacement Tip
How to Prevent Breaking the Fastener Hooks
Interior
Finding the Source of Interior Water Leaks
This can drive you crazy. Never assume anything. The leak may be coming from a place you would least expect
Interior
Auto Dimming Mirror Available for Older Benz?
Yes, for W107, W123. W126, W201 and W124 from 2phast Motorsports
Interior
Preventing Ignition Tumbler and Steering Lock Failure
Cleaning and proper lubrication can add years to your key tumbler and save you hundreds $$$
Interior
What Causes Those Sagging Front Seats?
And What Do I Needed to Fix Them?
Interior
W116 Sedan Power Window Failure
If motor is running most likely a broken regulator. Motor is not running see below
Interior
I Can’t Find the Rear Bolts to Get My Seats Out
If you don’t see the head of the bolt then you have to …
Brake Problems
Brake
Replacing Worn or Damaged Brake Mechanical Parts
Fixing brakes is not difficult and can save you hundreds
Brake
How to Diagnose Common Brake Troubles
Shake, side pull, binding, grabbing, grinding, squealing, overheating and soft / hard pedal issues.
Brake
Flushing Old Fluid and/or Excessive Air Out of Your Brake System
Efficient and affordable pressure bleeding, system flush and fluid capture is here for all.
Brake
Brake Rotor Chatter or Pulsation
Causes and cures for this common problem
Brake
Excessive Brake Pad Dust on Your Alloy Wheels
Can the problem really be solved? Kent has been on the hunt for a solution.
Brake
Determining If Your Brake Booster Has Failed
Don't be too hasty to buy a new one
Brake
Chasing Brake and Clutch Fluid Leaks
If you are losing brake fluid the source must be found quickly
Brake
Hydraulic Clutch and Brake Component Rusting
Clutch and brake fluid can be unkind to your cylinders and pistons
Brake
Kent Making Brake Fluid Flushing EASY!
You Have No Excuse Not To "Do It Yourself"
Brake
Classic Mercedes DIY Brake System Overhaul Part 1
Calipers First
Brake
Replacing Flexible Rubber Brake Hoses - ALL models
If over 15 years old then this is a must do job to prevent braking problems!
Brake
How Can Brake Caliper Bolt Be Dangerous?
Do they bite?
Brake
ABS Brake System Malfunction - ABS Light On
Some simple maintenance could help to solve the problem
Brake
Removing Stubborn Front Brake Rotors from Hub
Must be done anytime you replace front brake rotors
Brake
Why Clean and Lubricate the Hubs When Mounting Wheels
You'll learn why in this quick two minute video
Brake
Extracting Fluid from Brake Reservoir, Power Steering Reservoir and Automatic Transmission
After looking for years Kent has finally come up with the ideal no-spill fluid extractor
Brake
Losing Brake Fluid During Brake Hose and Caliper Replacement
Some simple precautions can save a big mess and ease brake system bleeding
Brake
Preventing Front Fender Damage from Brake Fluid, Scratches and Dings
A good soft fender cover is the BEST solution!
Brake
Why Parking Brake Shoes Wear Out or Fail?
No More Emergency Brake!
Brake
Protecting Your Health When Working on Brake Systems
This is not to be taken lightly!
Brake
What Are Your Brakes Telling You?!
There're telling you something and it's not the score of the ball game.
Brake
How to Fully Inspect Your Brakes
And How to Speak Brake Language
Brake
Avoiding Brake Caliper Seizure
There are some signs that will let you know your calipers are locking up.
Body and Exterior Trim Problems
Body and Exterior Trim
Fixing the Tilting Sunroof
A true challenge - but you can do it with the right knowledge.
Body and Exterior Trim
Badly Oxidized and Faded Aluminum Window Trim
It can be restored but it takes a special power tool and hard work
Body and Exterior Trim
Malfunctioning Non-Tilting Sunroof
Nothing like a good smooth working power or manually operated non tilting sunroof (up to 1985)!
Body and Exterior Trim
Tilting Power Sunroof Panel Removal and Replacement
The panel must be removed to properly repair and/or lubricate the tilting arm mechanism.
Body and Exterior Trim
Avoiding Buying a Rusty Mercedes in the First Place
Be careful or you could end up losing big time
Body and Exterior Trim
W116 W123 and W126 Chassis Wiper Drive Mechanism Failure
Regular cleaning and lubrication is the key to long life
Body and Exterior Trim
Hood Pad Removal and Installation
They are ugly when deteriorated - beautiful when replaced properly!
Body and Exterior Trim
Restoring Faded Plastic, Chrome and Body Paint Imperfections
If is seems too good to be true - then in this case it is true!
Body and Exterior Trim
Opening Up Stuck Doors on Old Mercedes
Most common when car has sat outside for long periods without use
Body and Exterior Trim
Missing Hold Down Plates for the W123 Battery Tray
Easily lost or rusted out - hard to find replacements
Body and Exterior Trim
W123 W126 W201 W124 Chrome Grill Strip Alignment
Tired of seeing little gaps show up?
Body and Exterior Trim
Station Wagon Rear Hatch Won't Open or Stay Open
This applies to the W123 240TD, 300TD and 280TE and the W124 300TD, 300TE, and E320TE.
Body and Exterior Trim
How to Make Your Silver Alloy Wheels Look New
And On A Budget Your Wallet Won't Mind
Body and Exterior Trim
Finding the Best General Purpose Trim Adhesive
This one has just the right combination of benefits
Body and Exterior Trim
What is the Best Older Mercedes Benz to Buy?
Kent believes there is no one correct answer. Just too many options...lol
Body and Exterior Trim
Opening a W124 Chassis Hood Up Into the Vertical (Service) Position
Not difficult once you do it. Be careful to avoid damage to the hinges
Body and Exterior Trim
Why Does My W116 Door Open Soooo Hard?
It may require a simple adjustment that you can do yourself
Body and Exterior Trim
How to Jack Up an Airmatic Mercedes That Has Dropped Down on the Ground
And No, This is Not The Latest Dance Move
Body and Exterior Trim
Rust Along the Inside Bottoms of the Doors
Stop it BEFORE bubbles in the paint and holes start to appear!
Body and Exterior Trim
Finding your Mercedes Factory Paint Color Code
This can sometimes be a real challenge if you do not know where to look
Body and Exterior Trim
Why Drive a Mercedes Benz?
Until you have driven one it is hard to explain
Body and Exterior Trim
Understanding the Difference Between a Non-Tilting Verses a Tilting Sunroof
Both are repairable by the DIY mechanic with the right knowledge and supplies.
Body and Exterior Trim
Comparing a W108 6 cylinder to a W109 Big V8
They look the same except for a just a few major differences!
Body and Exterior Trim
Why You Should Lubricate Your Outside Rear View Mirror: W126 Driver's Side Shown
Body and Exterior Trim
Why Did I Make A Custom Lubricant Cary Case?
So That I Know I'll Have What I Need Without Wasting Time!
Body and Exterior Trim
Foam Hood Pad Installation Tip - Edges Tucked in Without Damage
Body and Exterior Trim
Troublesome Trunk Seal Leaks
Be sure to look UNDER the trunk seal - you might be surprised!
Body and Exterior Trim
Priming a Repaired Dent on a Budget
You don't have to use expensive spray equipment or 2 part expensive primer
Body and Exterior Trim
Freeing up a Sticking Tilting Sunroof Panel
It may be something very simple like this
Body and Exterior Trim
Why Should I Troubleshoot and Repair My own Mercedes?
And Spare Your Wallet
Body and Exterior Trim
How to Remove Fine Windshield Wiper Scratches with Less Mess and Less Heat
Body and Exterior Trim
The Most Overlooked Water Drain on Older Mercedes - Leads to Water and Smell Where?
Body and Exterior Trim
Check Your Mercedes W126 Front Windshield Water Drains
Body and Exterior Trim
Kent's Secret Weapon in the Fight Against Removing Rusty Nuts and Bolts
Body and Exterior Trim
Exhaust System Rubber Hanger (Donut) Install Tool That REALLY Works! By Gerson Nolasco
Body and Exterior Trim
Mercedes W201 Chassis 190E 190D Hood Strut Replacement Procedures
Body and Exterior Trim
How to Get a Deep Shine on Older Faded Paint
In most cases it is a two step process - especially if your paint is faded.
Body and Exterior Trim
What is That Clunking Noise in My Rear End When Driving Over Rough Ground???
But When I Crank My Music All The Way Up I Miraculously Goes Away!
Body and Exterior Trim
Boregard's Benz Chronicles: Potential Freeway Disaster Averted on His 240D.
Body and Exterior Trim
How to Determine Quickly if the Car Has Ever Been in an Accident
Body and Exterior Trim
How I Restore Old Aged Exterior Black Plastic and Rubber Trim
Body and Exterior Trim
Fixing the Most Annoying Problems on Your Old Mercedes
Most in this list are avoided due to cost - Fix them yourself with our kits and save hundreds $$$.
Body and Exterior Trim
Side Body Trim Strip Removal and Repair
With the right tools and parts you can fix this nagging problem yourself
Body and Exterior Trim
Buying a Newer Used Mercedes Loaded with Computers
It is not as scary as you would think and the deals out there are amazing
Body and Exterior Trim
Adjusting the Power Tilting Sunroof
This covers most models with electric sunroofs from 1986 to 1995
Body and Exterior Trim
Failed Door Check Straps on the W116 Chassis
Easy to test - then easy to replace once you get the door panel off.
Body and Exterior Trim
What to Do With Small Hidden Rust Spots?
If caught early enough they can be easily fix permanently with Miracle Paint
Body and Exterior Trim
How to Safely Remove Rusty Nuts and Bolts without Breaking Them Off!
Body and Exterior Trim
What is The Best Way to Remove Chrome Side Body Trim Strips on Older Mercedes Benz
Body and Exterior Trim
How to Prevent Rust Out Holes in Your Sunroof Water Courses and Drain Tubes
Body and Exterior Trim
Introduction to the Use of Miracle Paint in Repairing Rust on Older Cars
Body and Exterior Trim
How Best to Handle Tough Car Problems
Just take a break!
Body and Exterior Trim
Getting Your Car to REALLY Shine
There is one amazing product Kent recently found that polishes it all!
Body and Exterior Trim
Best Way to Jack up and Support the Front End
W124 Chassis procedure shown here but applies to many models
Body and Exterior Trim
Can't Open Hood Because the Release Cable is Broken
There is a way to do it without damaging anything on many older models
Body and Exterior Trim
How I Remove Stick On Auto Pinstriping Without Damaging the Paint.
Body and Exterior Trim
Raining W126 300SDs in PNW: This One is Looking Better In Spite of Hood Damage
Body and Exterior Trim
My Compact All Purpose Deluxe Lubrication Kit Contents Explained
Body and Exterior Trim
Avoiding Expensive Mistakes Buying a Used Mercedes Benz
The best way to save money is to buy the right car in the first place
Body and Exterior Trim
W123 and W126 Hood Hinge Operation and Maintenance
2 Primary reasons these hood hinge assemblies fail
Body and Exterior Trim
What is Causing Excessive Moisture in My Trunk
It could be coming from a number of places for a number of reasons
Body and Exterior Trim
Where to Find a Nice Old Benz for Sale?
Kent is selling a few of his favorites that he does not have time to finish.
Body and Exterior Trim
How to Get a New Hood Pad on Straight
When using contact cement you have one shot to get it right! Kent's video will show you how to prevent mistakes.
Body and Exterior Trim
New Sunroof Seal Does Not Fit Right
It could be that you installed in upside down
Body and Exterior Trim
How Do I Minimize Corrosion on Magnesium / Aluminum Engine Parts
Body and Exterior Trim
What Maintenance is Required Once I Purchase an Old Diesel?
Body and Exterior Trim
Can't Get My Sunroof Cable Out
My sunroof motor does not run or it runs but the cable does not move
Body and Exterior Trim
Tow Dolly Safety: Why This? Why That? You Should or You Should Not!
Body and Exterior Trim
1977 to 1985 Mercedes W123 Rear Bumper Safety Alert
Body and Exterior Trim
How to Get a Window Sticker Body Decal on Straight: Example Mercedes SL Convertible
Body and Exterior Trim
Exhaust System Rattles and Shakes
Fix it before it leads to major failure! Exhaust muffler found dead on road...
Body and Exterior Trim
Getting the Windshield Washer Nozzle Sprayer to Work Properly
It is simple to clean out the hole and adjust it with the right "tool."
Body and Exterior Trim
Removing the Rear Trunk Emblems
On 1973 to 1985 models this has to be done with care to prevent damage
Body and Exterior Trim
Sunroof Not Moving?
We have resources to help you fix both power and manual sunroofs yourself
Body and Exterior Trim
What's The Easiest Way to Prep Rusty Metal for Miracle Paint
And Say Bye Bye to Rust
Body and Exterior Trim
How to Troubleshoot Why Water is Getting Into Your Car
Body and Exterior Trim
How Do I Gently Remove Stuck Electrical Plug or Other Interior Switches?
Body and Exterior Trim
Hex Head Bolt Removal Tips: To Prevent Rounding Out the Head
Body and Exterior Trim
How to Clean Hard to Reach Water Drains With This Deep-Cleaning Tool
Body and Exterior Trim
Preventing Pre-mature Failure of Key Mechanical Components
Anyone want to guess what the secret is???
Body and Exterior Trim
Finding good used W116 Parts
Kent has some very sweet hard-to-find spares left over from his 300SD restoration
Body and Exterior Trim
How to Straighten Major Body Damage Enough to Get it on the Road
Depending on where the damage is you can do amazing things with jacks and hammers.
Body and Exterior Trim
How Do I Restore The Old Faded Black Plastic and Paint Work on my Mercedes?
Body and Exterior Trim
What is Kent's Favorite Chop Saw Abrasive CutOff Wheel for Tool Steel
Body and Exterior Trim
I Got New Chrome Side Trim on My Old Mercedes But They are Loose!
Body and Exterior Trim
Repairing Early Diesel Front End Damage
This is not expensive if you find used parts and do the work yourself!
Body and Exterior Trim
Removing Glued on 123 Chassis Front Fenders
Tough job and you will need heat! Also applies to 107, 114, 115, and 116 chassis
Body and Exterior Trim
Best Older Mercedes Diesel to Drive?
Kent shares three of his favorites
Body and Exterior Trim
How to Tell if Your Sunroof Seals Need Replacing
Knowing what to look for will help you decide if replacement is needed
Body and Exterior Trim
Stopping and Detailing the Surface Rust Under a Car
You can do this in your own driveway with minimal tools and experience
Body and Exterior Trim
Where to Start Your Restoration?
Start with something you can do yourself that is not super difficult and gives dramatic results.
Body and Exterior Trim
How Do I Deal with Rusty Lug Bolt and Hub Threads
Body and Exterior Trim
My Case for the AGM (Absorbent Glass Mat) Battery
Body and Exterior Trim
1966 to 1985 Mercedes Sunroof Seals Complete Installation Kit with Instructions and Extras
Body and Exterior Trim
Missing W123 Battery Hold Down Clamps
You are not alone! What can you do to replace those rusty or missing metal clamps
Body and Exterior Trim
Why The Heck Should I Put Magnets on My Mercedes?
Body and Exterior Trim
What Can I Do To Make The Inside of My Car Door Almost New Again?
Body and Exterior Trim
Best Pad Applicator for Automotive Waxes, Sealers, and Protectants
Body and Exterior Trim
Hunting For Classic Mercedes Don't Believe the Odometer! Clues for High Mileage Cars
Body and Exterior Trim
How to Fix Hidden Rust Under the Bumpers and Battery
Body and Exterior Trim
Door Latch / Catch Failure
Failure is almost always caused by corrosion due to high moisture environment and lack of lubrication
Body and Exterior Trim
What Do I Do When Getting My Body Under a Car?
- DIY Repair Safety -
Body and Exterior Trim
Best Applicator for Lubrication: Long Live the Curved Tip Syringe
Body and Exterior Trim
Dressing Up the Front End
Small fixes can lead to a large cummulative visual improvement
Body and Exterior Trim
Manual Operating Sunroof Service and Repair
Ignore it and you will be sorry! Can you remove and service it yourself?
Body and Exterior Trim
Figuring Out How to Get a Trunk Emblem Off
It is a little tricky and very easy to damage it.
Body and Exterior Trim
Filling a Dent with Minimal Effort
Put the body filler on in two phases and manage the time when you grate and sand it
Body and Exterior Trim
How Do I Make A Quick Emergency Hood Release Kit
Body and Exterior Trim
Can Make Your Alloy Wheels Look Like This on a Sat. Afternoon?
I Know You Can!
Body and Exterior Trim
Super Weatherstrip Adhesive Put to the Test
Body and Exterior Trim
How to Protect Your Diesel Engine Rubber Motor Mounts
Body and Exterior Trim
Finding Interior Color Codes
Location of the three digit numerical code and translation here
Body and Exterior Trim
Removing Plastic Body Fasteners
The right tool can do the job without damage
Body and Exterior Trim
Removing Damaged Door Striker Plate Bolts
Easy to round out the hex head bolts - then what do you do ?? !!!
Body and Exterior Trim
How to Protect Your Car's Paint When Working on the Engine?
Nothing is better than a good thick fender cover
Body and Exterior Trim
What Is Wrong With My W203 C Class Tailgate Lock?
And How Do I Fix It?
Body and Exterior Trim
How to Fix a Noisy Snapping Door Check Strap
Body and Exterior Trim
Can Tire Bead Sealer REALLY Fix Leaking Chrome Alloy Wheels?
Body and Exterior Trim
How to Get a Benz to REALLY Shine
Kent recently discovered one product that shines above all the rest
Body and Exterior Trim
Better Way to Clean Corrosion on Alloy Wheel and Hub Mounting Surfaces
Fuel Delivery Problems
Fuel Delivery
Testing Diesel Fuel Injectors for Peak Performance
You will need a bench mount pressure release tester to do this yourself.
Fuel Delivery
Diesel Engine Fuel Filters
Major cause of sudden loss of power
Fuel Delivery
Diesel Engine Fuel Leaks
The sources of fuel leaks and procedures needed to repair them are many
Fuel Delivery
Fuel Restriction at the Internal Fuel Tank Filter Screen
A plugged filter inside your fuel tank can lead to hard starting and power loss
Fuel Delivery
Diesel Engine Prechamber Collar Nut Fuel Leaks
A unique special tool so affordable every diesel owner should have one
Fuel Delivery
102 103 104 Gas Engine Difficult or Slow to Start
Begin with the "back end" fuel delivery system first.
Fuel Delivery
Early V8 Gas Engine Back End Fuel Delivery
Fuel pump, filter and related components most likely will need your attention on 25+ year old Mercedes
Fuel Delivery
Banjo Fitting Care and Maintenance
Fuel Line and Transmission Cooler Line Leak Prevention
Fuel Delivery
Testing Gas Engine Mechanical Fuel Injectors on than Mercedes Benz
If you car uses a Bosch mechanical fuel injection system then our tester will work!
Fuel Delivery
Gasoline Fuel Smell in the Engine Compartment
Find the source and fix immediately to avoid an engine fire!
Fuel Delivery
What to Expect When Getting An Old Diesel Running after Sitting for Over Three Years
Depends a lot on the climate and how the car was stored but you should always begin with new fuel and filters
Fuel Delivery
1977 to 1980 Mercedes Fuel Injection Delivery System Overhaul on the Bench: Before and After
Fuel Delivery
How Can I Tell If My Fuel Injectors Need to Be Rebuilt?
Do They Need New Nozzles?
Fuel Delivery
How to Borrow a Little Fuel from One Diesel to Get Another Running Without Using the Factory Tanks
Fuel Delivery
1959 to 1975 Mercedes Electric Fuel Pumps
Problems that Can be Solved
Fuel Delivery
Diesel Injector Return Hose End Plug
How to make your own in a pinch
Fuel Delivery
Using Diesel Purge: The Best Medicine for a Sick Diesel Engine
Learn how this works so well and how you can do it yourself
Fuel Delivery
601 602 603 Injection Pump Delivery Valve Seal Replacement
Common fuel leak problem but repair must be approached with care
Fuel Delivery
Fuel Tank Inspection and Service
Very important for cars over 20 years old.
Fuel Delivery
Leaking or Stuck Late 1960's Electric MFI Fuel Pump
All too common problem with these old gas fuel injected cars
Fuel Delivery
How Can You Tell if There is Algae in Your Diesel Fuel Tank?
Here are some ways to inspect for and prevent algae growth
Fuel Delivery
Dirty and Plugged Up Fuel Tank
Lack of attention here will leave you stranded on the road!
Fuel Delivery
Improving Diesel Engine Power Performance
Already done filters, injectors, tuning and still want more power - there is one more thing you could do.
Fuel Delivery
CIS FID Fuel Accumulator Opened Up
You Won't Believe What's Inside!
Fuel Delivery
Fueling Your Old Diesel from a Fuel Container
Try to do this without spilling fuel on your car and all over the ground!
Fuel Delivery
Diesel Fuel Injector Pressure (Pop) Tester Not Holding Pressure
There are some things you should do or not do for long service life
Fuel Delivery
How to Be Assured of a Quality Diesel Mechanical Fuel Injector
You need to look no further than the precision nozzles produced by Monark of Germany
Fuel Delivery
Best Primer Pump AND Best Tool For Quick Installation
And Easy Installation
Fuel Delivery
Diesel Engine Timing Device
This important device is not immune to problems as the older diesel engines age!
Fuel Delivery
Removing and Installing a Diesel Engine Hand Primer Pump
This can be a frustrating challenge without the right tools.
Fuel Delivery
Mercedes OM617 Diesel Injection Pump ALDA Replacement
Fuel Delivery
Diesel Engine Taking Too Long to Start in the Morning
If you know your glow plugs are working properly it could be a fuel pressure issue
Fuel Delivery
Emergency Plug for a Fuel Hose
You will be amazed how well this works!
Fuel Delivery
Diagnosing Diesel Engine Fuel Injectors
How do you know if they are bad? If they have not been recently rebuilt they probably are!!!
Fuel Delivery
Tuning Rough Running C.I.S. Gas Fuel Injection
Here are some things you should look out for!
Fuel Delivery
How to Accurately Set Diesel Injection Pump Timing
With the right tools and procedure you can get precise results yourself
Fuel Delivery
Improving Mileage and Performance on Your Older CIS Injected Benz Gas Engine
Most owners forget about the fuel injectors - Cap, rotor, wires and plugs may not be enough
Fuel Delivery
How to Thoroughly Clean Gas CIS Fuel Injectors
Some will need to be "back flushed"
Fuel Delivery
What Oil Should I Use in My Old Injection Pump
1976 and older Mechanical Injection Pumps had their own oil supply.
Fuel Delivery
Is It Difficult or Expensive to Rebuild My Own Fuel Injectors?
No, Not With My Pop Tester!
Fuel Delivery
Old Diesel Won't Start After Fuel Starvation or Filter Change
You have to be sure all air is removed from the fuel lines and hoses
Fuel Delivery
Gas Engine Fuel Smells in Car
This one you definitely do not want to ignore!
Fuel Delivery
Hard Starting and Rough Running Gas Engine with C.I.S. Bosch Fuel Injection
Sometimes it can be something quite simple - other times not...
Fuel Delivery
Why Remove the Mercedes W123 Fuel Tank Sending Unit?
Especially When It's So Easy?
Fuel Delivery
Fuel Leaks Between Diesel Fuel Injector Body Halves
More common than you think and easy to fix with right tools
Fuel Delivery
1986 to 1993 Diesel Engine Fuel Heater Leaking in Engine Compartment
This is a very common problem on the 602 and 603 diesel engines
Fuel Delivery
Fuel Leaks at Rear of Car
Fix at first sign of wetness under car - BEFORE total failure
Fuel Delivery
Stopping Fuel Leaks when Performing a Diesel Compression Test
The fuel from the injection pump can be shut off by following this tip:
Fuel Delivery
Removing Stubborn Diesel Fuel Injector Heat Shield Washers with Special Tool
Applies to all 200D 220D 240D 300D 300CD 300TD 300SD 190D 300SDL 350SD and 350SDL
Fuel Delivery
Rebuilding Diesel Injector Nozzles - Warnings and Advisements
Must read info BEFORE you rebuild your injector nozzles
Fuel Delivery
My Gas Engine is Running Too Rich ( Excessive Fuel Mixture )
Kent shares 3 indicators of an excessively fuel rich running gas engine
Fuel Delivery
My OM617 Turbo Diesel Does Not Produce Good Power and Smokes Too Much
These are signs your turbo over boost protection system is not working properly
Suspension Problems
Suspension
Determining Parts Needed to Fix Loose 123 Chassis Front Suspension
Parts breakdown will help you find what you need fast
Suspension
Determining Parts Needed for Loose 126 Front Suspension
Know what to look for and understand the parts you will need
Suspension
Diagnosing and Repairing Hydraulic Self Leveling Suspension (SLS )
If you have a Mercedes station wagon and want to use it to haul loads best to fix it right
Suspension
Diagnosing Loose Front End Steering
Inspect the tie rod ends first for wear
Suspension
W126 Chassis Front End Clunking Due to Support Rod Joint Failure
Very very common on those chassis with over 150,000 miles
Suspension
Avoiding a Slipping Jack or Jack Stand When Raising Your Benz
This is what Kent uses and you can build it yourself!
Suspension
Worn Front Lower Sway Bar Bushings
Replacement is an easy and inexpensive DIY repair that improves handling
Suspension
2000 to 2006 Airmatic Front Suspension Loose
Suspect one or more worn rubber bushings
Suspension
Hard to Remove Tie Rod Ball Joints
It may take a special tool
Suspension
Trying to Determine the True Mileage of an Old Benz
The odometer can lie. Don't be fooled and make an expensive mistake!
Suspension
W210 4matic Front Shock Replacement
This can be one super tough and expensive job without the right tool and know how
Suspension
How to Prevent Your Alloy Wheels from Rusting to the Hubs
Something simple to save so much grief
Suspension
What is the best glove for working on your car?
Tips on how to make the gloves last longer!
Suspension
123 and 126 Chassis Front Torsion Bar Failure
Alert! Check yours before experiencing a dangerous suspension failure
Suspension
Catastrophic Front Suspension Failure
123 and 126 Chassis Owner's Alert
Suspension
Mounting a Mercedes Wheel on the Hub
This can be frustrating without the right tool. Yes, there is a tool!
Suspension
Diagnosing Strange Front End Rumbling Noises
Suspect front wheel bearings
Suspension
Restoring a W126 Chassis Diesel
Kent shows some of the initial things he had to do to his own 1987 300SDL
Suspension
How to Do a Front Air Spring Inspection
Know What to Look For
Suspension
Trailing Arm Failure: WARNING!
On most models 1973 to 1991 trailing arms can collapse leading to dangerous consequences
Suspension
How to Make Your Alloy Wheels Look This Nice?
Not as hard or expensive as you might think. And yes, you can do it yourself!
Suspension
Rescuing a 116 Chassis 450SEL 6.9
Amazing cars but be prepared to spend some money.
Suspension
No Room to Install a New Shift Rod Bushing on the Transmission
Sometimes you can only do it with our special tool - a few occasions you have to drop the rear of the tranny
Suspension
Have An Air Suspension Leak? Here's How to Make Your Own Emergency Block!
A Mercedes Saving Quick Fix
Suspension
Broken Studs and Damaged Threads in Rear Sway Bar Links
This happens often enough you need to know the options available for repair
Suspension
Mercedes Rear Differential Maintenance Tip
If You Hear Clunking Check This!
Suspension
SLS Suspension Riding Rough - How to Test Accumulators.
It is possible to test their condition on the car
Suspension
6.9 Hydraulic Suspension Diagnosis and Repair
Here is what you have to deal with when owning this brute
Suspension
Loose and Rattling Exhaust System
Failure to replace the donuts could leave your exhaust dragging on the ground!
Suspension
Clunking Noise In Rear Suspension When Going Over Bumps
It could be a number of things including shock absorbers
Suspension
How Bad Shocks Ruin Other Suspension Parts
Rust / Corrosion Problems
Rust / Corrosion
Miracle Rust Repair for Your Old Mercedes
Yes there is! Miracle Paint and fiberglass cloth can work miracles.
Rust / Corrosion
Rocker Panel and Floor Permanent Rust Repair without Welding
You can do it yourself without the hassle and bad side affects of welding!
Rust / Corrosion
Welding in New Sheet Metal When Repairing Rust Out
Not always the best solution as you will see here.
Rust / Corrosion
What to do When you Get Tired of Working on Your Benz
Sometimes You Just Need to Go Have Some Fun!
Rust / Corrosion
Fixing Rust: Learning the Many Uses of Miracle Paint
It works on any type of rust - on any iron based metal - on any vehicle or part
Rust / Corrosion
How to Prevent Miracle Paint from Getting Hard in the Container
You have to keep the air away from it
Rust / Corrosion
Best Way to Prevent Water From Getting into Your Benz
Easy preventative maintenance you should do at least every six months... unless you live in the desert..:-)
Rust / Corrosion
123 Battery Box Area Rust
Do NOT neglect inspecting and repairing this area or you will be sorry!
Rust / Corrosion
Stopping Small Areas of Rust BEFORE They Become Holes in The Body
It is all about prevention. Remember rust never sleeps!
Rust / Corrosion
How to PM
Preventing Coolant Pipe And Radiator Hose Nipple Corrosion
Rust / Corrosion
Keeping the 123 Engine Compartment Front Water Drains Clear
Failure to do this can lead to big problems on these models
Electrical Problems
Electrical
Diesel Engine Glow Plug Timer Relay Failure - Options for Repair
Here is an option to replace the pre-glow factory unit with a reliable manual controlled relay
Electrical
Troubleshooting an Electrical Problem
Unknown battery drain, electrical shorts, blown fuses - these can be difficult to isolate!
Electrical
O.E. Aluminum Fuse Failure
One of the most common problems we see on older Mercedes.
Electrical
126 Chassis Sedan Window Glass not Moving Up and Down
Common to all 126 sedans 1981 to 1991 - you hear the motor mechanism running but glass is not moving or it's binding
Electrical
Weak U.S. Round or Square Headlights on 1985 and Older Models
Installing H4 headlight upgrades will make a difference between night and day
Electrical
Knowing How to Use the Cruise Control Lever on Older Mercedes
We share with you the factory instructions for most models from the late 1970's to late 1980's
Electrical
Service Requirements for Power Antennas
Yes, they do need service if you want them to last.
Electrical
Replacing a Badly Burned Wiring Harness
Don't let anyone kid you... this is not an easy job!
Electrical
My New Power Antenna is Not Working
It just may not be wired properly. Most likely it is NOT the antenna.
Electrical
New Tumbler Installed and Key is Stuck - HELP!
We are getting too many emails like this usually after parts are bought somewhere else
Electrical
Mercedes W124 Owners - Learn How to Get to Terminal Block X30 to Troubleshoot Electrical Problems
Electrical
Battery Staying Charged During Prolonged Vehicle Storage
You have a couple options to keep the battery alive!
Electrical
Removing a W123 Fuse Box Cover
Talk about a Chinese jig saw puzzle. Kent can show you the trick
Electrical
Fuse Repeatedly Burns Out?
Isolate the source of the short to finally solve your problem
Electrical
Best Battery for Your Mercedes Benz
Technology is constantly changing and Kent now recommends exact fit AGM batteries
Electrical
Can I Get Some Tips on Alternator Voltage Regulator Replacement?
For The 1998 to 2006 Years?
Electrical
Removing a W123 Diesel Big Battery
Can it really be all that difficult?
Electrical
Frequent Glow Plug Failure
If you are constantly having to replace glow plugs do not immediately blame the plugs! Ream the carbon!
Electrical
Buffing and Sanding in Tight Places
This is one of Kent’s favorite tools to have around the shop
Electrical
Premature Glow Plug Failure
If it is happening on a regular basis it probably is not bad glow plugs
Electrical
Pulling DTCs (Diagnostic Trouble Codes) from the Check Engine Light
Using an inexpensive code reader or scan tool is not difficult
Electrical
Cleaning Up Ugly Battery Post Corrosion
You can do it with commercial products or something in the cupboard
Electrical
Properly Maintaining an Old Car Battery
Neglect is probably the No. 1 Cause of your Benz not starting
Electrical
Engine Won't Turn Over When It Sits Overnight
Do not assume it is just a bad battery! Diagnose first...
Electrical
My Case For the AGM Battery
Electrical
Charging a Totally Dead Battery
Some chargers won't start the charge cycle without some help
Electrical
Mono Windshield Wiper Gear Failure
Preventative maintenance is the key to long life
Electrical
201 and 124 Chassis Tail Light Malfunction
It is not always the bulb or the wiring.
Electrical
Key Not Springing Back From the Start Position
This is a sure sign your electrical switch is going bad
Electrical
Lost 116 and 123 Fuse Box Location Chart
Knowing what fuse does what is a must when troubleshooting electrical problems
Electrical
Power Antenna Failure
There is a quick fix as well as a more permanent repair
Electrical
Removing the Buzzer Switch From an Ignition Lock Assembly
Not as easy as it looks and easy to break if you don't know the proper tricks
Electrical
What Might be Wrong With my Early W220 Engine Fan?
No Need to Spend Big $$$
Electrical
Removing a Tumbler from a Steering Lock if the Key Won't Turn
It is possible to do this but you have to cut the black cap off first.
Electrical
Rear Door Power Window Failure
Do proper testing BEFORE ordering parts or removing door panel
Electrical
Fixing or Replacing a Broken Hirschmann Power Antenna
Originals are hard to fix and not available new - Universal new antenna may be best option
Electrical
Best Way to Fix a Non-Working Odometer or Speedometer
Kent recommends just sending it out for professional repair
Electrical
How to Open up and Clean Old Electrical Plugs
Corrosion on the contacts can cause all kinds of electrical problems
Electrical
How to Connect a Battery Maintainer / Tender up to the Newer Models
That have a different style battery clamp
Electrical
Car Alarm Keeps Going Off
Sometimes it is just easier and less expensive to disable it
Electrical
Rear Door Power Window Failure
Do proper testing BEFORE ordering parts or removing door panel
Electrical
What Could Go Wrong When Changing an Ignition Switch or Steering Lock??
If the wiring plug falls apart on you, you won't know what coded wires go where!!!
Electrical
How Can I Save My Expensive Dead Battery?
It is possible to save a Big $200 AGM battery with the right know-how!
Electrical
How Do I Repair My Hirschmann Antenna?
And What Parts Do I Need?
Electrical
Can You Start an Older Mercedes without a Key?
Maybe with some "Magic"
Electrical
OM 636 Diesel Engine Slow Starts
Tired of it taking sooooo long to heat up your glow plugs
Electrical
Testing Diesel Engine Glow Plugs for Proper Operation
Burned out glow plugs, bad pre glow relay, blown fuse, wiring - all need to be tested
Electrical
Ignition Switch Wire Plug Comes Apart Accidentally
You will need a wire schematic to figure out which wires go into which holes
Electrical
Can You Start an Older Mercedes without a Key?
Maybe With Some Kent Magic?
Electrical
Car won't start due to a dead or drained battery?
Part 2: Best Charger and solutions for Battery drain
Electrical
Tachometer Not Working in 1978 to 1984 Mercedes with OM 617 Turbo Diesel Engine
In his YouTube video Kent covers the most common problem areas
Electrical
Problems with Glow override Solenoid Relay Installation - How to Test
Kent will show you some quick checks to test operation
Electrical
Inaccurate or Erratic Fuel Gauge
This could be caused by one or even a combination of three things.
Vacuum Problems
Vacuum
126 Chassis Sedan Vacuum Door Lock Failure
Different from the 116 / 123 chassis and more difficult to troubleshoot
Vacuum
Determining Correct 1980 to 1985 Diesel Vacuum System Hose and Line Routing
When troubleshooting your vacuum system you must know where the hoses and lines go
Vacuum
123 Chassis Vacuum Door Lock Failure
A very common problem that requires precise troubleshooting
Vacuum
603 Diesel Engine Vacuum Hose Leaks and Faulty Routing
If the hoses are leaking or are not hooked up properly a number of problems could occur.
Vacuum
What is Causing Diesel OM616 and OM617 Vacuum Pump Failures?
Pump mechanisms breaking apart and piston bolt failures
Vacuum
Overhauling a W116 300SD Engine Driven Vacuum Pump
Repair kits and parts are not available new for the twin diaphragm pumps
Vacuum
Vacuum Line Under Dash Not Plugged into Anything!
Common concern on 1980 to 1985 Mercedes Diesel 240D, 300D, 300CD, 300TD
Vacuum
Constantly Failing Diesel Vacuum Pumps
Look for the cause in the drive mechanism
Vacuum
Fixing W116 and Early 123 Door Locks
#1 Failure Point are the rubber diaphragms in the door lock actuators
Vacuum
Keeping Mice Out of Your Car
Double check for damage and use a product to scare them away
Vacuum
How to Test a W123 Vacuum Door Lock Actuator
Easy to test when out of car. See Kent's manual to learn how to test without removing door panel.
Climate Control Problems
Climate Control
Intermittent Cabin Heat - Second Generation Climate Control
Applies to late 123 and 107 chassis and all 126 chassis 1981 to 1991
Climate Control
Intermittent or No Cabin Heat - First Generation Climate Control
No heat or heat all the time are common problems with 1977 to 1980 models with automatic controls
Climate Control
Heater Blower Motor Won't Run
A common problem on all models. Options for repairing it yourself and saving big $$$.
Climate Control
W140 Heater Blower Motor Won't Run
Learn the correct procedure to determine how to fix the problem
Climate Control
Climate Control Servo Repair Options for Mercedes Benz
Climate Control
Why is My Heater So Sporadic?
Most 1981 to 1991 Mercedes Benz
Climate Control
Location and Replacement of Cabin Air Fitlers
These really get neglected and they are easy DIY
Climate Control
Why Don't My Early Auto Climate Control Fan Motor Buttons Work
Climate Control
Dirty Cabin Air Filters 1996 to 2006
Where are they located and how do you change them yourself?
Climate Control
Late W124 Chassis Heater Blower Motor Repair
There is no inexpensive fix for the 1994 and 1995 E320, E420 or E300D
Climate Control
W123 Blower Heater Motor Won't Run
This applies to the 1977 to 1985 240D 300D 300CD 300TD 280E and 280CE.
Climate Control
How Do I Test My 1977 to 1995 Auxiliary Electric Water Pump
SVO / Biodiesel Problems
SVO / Biodiesel
Installing a Mercedessource Diesel to Vegetable Oil Fuel Conversion
We offer an easy to install kit or you can build one from our components
SVO / Biodiesel
Converting an Older Mercedes Diesel to Run on Vegetable Oil (SVO) Using the Mercedessource STC Kit?
Questions and answers to help you decide if this is right for your diesel
SVO / Biodiesel
Running your Diesel Engine on Straight Vegetable Oil
The pros, cons, effort, and expense of running your Mercedes Diesel on waste vegetable oil
SVO / Biodiesel
Sorting Out the Claims When Considering a Diesel to Vegetable Oil Conversion
Here are some tips to considering when putting together your own conversion
SVO / Biodiesel
How to Run Waste Cooking Oil in Your Diesel With Only One Fuel Tank?
Mercedes diesel engines are the only ones well suited for one tank operations
SVO / Biodiesel
Diesel to WVO / SVO Conversion Fuel Starvation
List of possible causes and remedies for hard starting and loss of power
Driveline and rear end Problems
Driveline and rear end
Drive Line Flex Disk Deterioration and Catastrophic Failure
Start with inspection and replace at first signs of wear to prevent expensive damage to transmission
Driveline and rear end
Diagnosing and Repairing Common 114 115 107 116 123 and 126 Rear End Problems
The Differentials are very rugged. It is the associated parts that usually fail due to age and high mileage
Driveline and rear end
Avoiding 201 and 124 Chassis Flex Disk Trouble
Watch for signs of impending failure
Driveline and rear end
How Do I Reduce Vibration on My Benz?
Driveline and rear end
1996 to 2006 Mercedes Benz Part 18: Front Engine Noises
Driveline and rear end
Installing Shift Rod Bushings - What Does Not Work
Nothing like having the right tool
Driveline and rear end
Raining W126 300SDs in PNW: Doing This Really Helps Massage the Brain!
Driveline and rear end
1970's to 2000 Rear End and Rear Suspension Component Failure
Knowing your rear suspension design and theory will help troubleshoot a problem
Driveline and rear end
Worn Out Rear Axles
Best way to test them is out of the car on the bench
Driveline and rear end
Rear End Clunking Noises
Sign of worn part when driving over rough ground
Driveline and rear end
Can or Should I Replace My Rear Axle Boots?
If the axle joints are still good new boots are sometimes a good solution
Driveline and rear end
Mercedes Driveline Inspection & Component Location Explained by Kent Bergsma
Lights Problems
Lights
How Can I Easily Restore My Euro Headlights?
You'll wonder "why didn't I do this earlier"?
Lights
What If It Is NOT My Dash Light Bulbs
If your dash is not lighting up at night it could be a number of problems
Lights
What to Do with Rusty or Faded Tail Light and Fog Light Reflectors
Tail lights we are talking all models from 1960s to Mid 1990's - Fog lights only on those with removable lenses.
Lights
LED Dash Instrument Light Testing:
Mercedes W123 W126 W201 W124 - Always Looking for Better!
Lights
Really Dim Pre 1985 Headlights
If your car has the old style sealed beam headlights there is a great solution!
Lights
Dim 123 Instrument Lights
Here are some tips to help you brighten those instrument cluster lights
Lights
Moisture Buildup Inside Your Headlights
This can happen on a number of models for a number of reasons
Lights
Instrument Cluster Light Bulb Requirements
Knowing what bulbs you need and how to get to them is the key!
Lights
Preventing Rust from Forming Inside Your Headlights
Sometimes the fix can be real simple and real cheap.
Lights
123 Chassis Center Console Panel Light Bulb Replacement
Getting to those little bulbs can be challenging.
Lights
Replacing W116 Tail Lights Seals
Watch Kent's free video tip to avoid frustration
Lights
How Do I Inspect or Repair my License Plate Lights?
On a 1976 to 1985 W123 Mercedes
Lights
Replacing a Plastic Headlight Door Surround on a W126 or W124
Get rid of and change that ugly head light door yourself. What a difference!!
D-Jetronic Fuel Injection Problems
D-Jetronic Fuel Injection
1970 to 1973 W108 W109 3.5 and 4.5 Overhaul Fuel Delivery System
Upgrade Kit Available
D-Jetronic Fuel Injection
Early V8 Points to Electronic Ignition Conversion
Part 1 The Challenge
D-Jetronic Fuel Injection
1970 to 1975 D-Jetronic Fuel Injectors - Which Seals Do I Need?
D-Jetronic Fuel Injection
How To DIY Test Bosch D-Jetronic EFI Fuel Injectors
D-Jetronic Fuel Injection
Mercedes Porsche D-jet Electronic Fuel Injector Rescue
Watch Close Up
D-Jetronic Fuel Injection
How to Back Flush Pressure Clean Mercedes Electronic Fuel Injectors
Procedure Also Works on Porsches
D-Jetronic Fuel Injection
50-Year-Old Beautiful Mercedes D-Jetronic V8 Engine
Eye Candy for Gearheads
D-Jetronic Fuel Injection
1970 to 1975 Mercedes V8 Engine Compartment Fuel Hose Replacement
Scroll to see repair kit
D-Jetronic Fuel Injection
D-Jetronic Replacement Bolts for Fuel Injector Hold-Down Clamps
D-Jetronic Fuel Injection
Early Fuel Injected D-Jet V8 Engine Running Real Rough After Years of Neglect
D-Jetronic Fuel Injection
Cheap "Cad Plating" for Your Old Benz Engine Components
D-Jetronic Fuel Injection
Early Fuel Injected D-Jet V8 Engine Running Not So Good - Initial Troubleshooting
D-Jetronic Fuel Injection
Using Tight Wound Coil Wire
To Prevent Kinking and Chafing on Fuel Hose
D-Jetronic Fuel Injection
Early Fuel Injected D-Jet V8 Engine Running Not So Good - A BIG Problem Found and Fixed
D-Jetronic Fuel Injection
Fuel Pressure Testing Your Old V8?
WARNING: Most Gauges are NOT Accurate.
D-Jetronic Fuel Injection
Early Fuel Injected D-Jet V8 Engine Running Better After Timing Chain, Valve Adjust, and Plugs
D-Jetronic Fuel Injection
How to Custom Fit the New Shutter to Your Individual D-Jetronic V8 Distributor
A small file is all you will need
D-Jetronic Fuel Injection
1972 Mercedes 300SEL 4.5 Beauty Rescue Part 2
Dealing with the Nasty Fuel and Pump Components
D-Jetronic Fuel Injection
Mercedes D-Jetronic V8 Fuel System Depressurization
A better way to do it than you have been told
D-Jetronic Fuel Injection
How to Fix Leaking and Stuck 1970's Bosch Electric Fuel Pumps
D-Jetronic Fuel Injection
Mercedes D-jetronic V8 New Fuel Injection Set w/ Install Extras
D-Jetronic Fuel Injection
W108 W109 V8 EFI Fuel Pump Conversion
Yes There is a Solution!
D-Jetronic Fuel Injection
1972 to 1975 350SL 450SL EFI New Fuel Pump Conversion
Now Available!
K-Jetronic Fuel Injection Problems
K-Jetronic Fuel Injection
Help! What's Wrong With My Engine Part 2
More Details Here, But Still Hot Start Issue!
K-Jetronic Fuel Injection
Bosch C.I.S. Fuel Injection Testing and Repair Success Stories
K-Jetronic Fuel Injection
Help! Tell Me What's Wrong with My Engine Part 1.
Watch the Video!
K-Jetronic Fuel Injection
Help! What's Wrong With My Engine Part 3
I have already spent $$$. What to Do Now???
KE-Jetronic Fuel Injection Problems
KE-Jetronic Fuel Injection
KE-Jetronic 560SL Fuel Pressure Test
How to Bypass the Fuel Pump Relay?